Product ID:MIL-E-15145B ZINC DUST, 700A106
MSDS Date:05/01/1995
FSC:8010
NIIN:00-664-0020
Status Code:A
MSDS Number: CHVNC

GRIGGS PAINT

3602 S 16TH PL
PHOENIX, AZ 85040
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 602-243-3293

Preparer: ROBERT COMMISSO

Cage: DO312

GRIGGS PAINT

PHOENIX, AZ 85040-1319 US

Telephone: 602-243-3293

Cage: DO312

2.0 @ 68F.

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 43%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

5.1 @ 68F.

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 1%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM; 150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

4.16 LB/GAL (499 G/L)

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: BREATHING OF HIGH VAPOR
CONCENTRATIONS MAY CAUSE DROWSINESS, DIZZINESS, FATIGUE, FOLLOWED
BY COMA. MAY LEAD TO LUNG CHANGES, NAUSEA, VOMITING, COUGH,
PULMONARY IRRITATION & CNS DEPRESSION. EYE: DIRECT CONTACT &/OR
CONTACT W/VAPORS MAY CAUSE IRRITATION. SKIN: PRLNGD &/OR RPTD
CONTACT MAY CAUSE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: IRRITATION &/OR DERMATITIS. MAY BE
ABSORBED THRU SKIN; PRLNGD/RPTD EXPOS CAN CAUSE MODERATE
IRRITATION, DEFATTING & DERMATITIS. INGEST: ASPIRATION OF THIS PROD
INTO LUNGS MAY CAUSE PNEUMONIT IS, PULMONARY EDEMA & HEMORRAGE.
INGESTION MAY CAUSE GI DISTURBANCES. WARNING: THIS PROD CONTAINS
CHEMS KNOWN (SUPDAT)
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES IN OR HISTORY OF AILMENTS INVOLVING SKIN, CENTRAL NERVOUS
SYSTEM, LIVER AND KIDNEY.

First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . EYES: IMMEDIATELY FLUSH WITH LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL AID. SKIN:
WASH THO ROUGHLY WITH SOAP AND WATER. SEEK MEDICAL AID IF
IRRITATION PERSISTS. INGEST: IMMEDIATELY SEEK MEDICAL AID. DO NOT
INDUCE VOMITING. DO NOT ATTEMPT TO GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.

Flash Point Method:TCC
Flash Point:80.0F,26.7C
Lower Limits:1%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROTECTIVE EQUIP
. WATER MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CNTNRS. IF
WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO HEAT.

Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB WITH INERT MATERIAL. FLUSH
AREA WITH WATER. VENTILATE AREA FOR AT LEAST 24 HOURS OR UNTIL AREA
HAS BEEN DECLARED SAFE .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTAINERS CLOSED & UPRIGHT TO
PREVENT LEAKAGE. AVOID FLAMES, WELDING, OPEN LIGHTS, ETC. AVOID
BRTHG VAP & SPRAY MIST. AVOID SKIN & EYE CONTACT.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANK OR PIT WITHOUT ADEQUATE VENTILATION.

Respiratory Protection:IF VENT DOES NOT MAINTAIN INHAL EXPOSURES BELOW
TLV(PEL), USE NIOSH APPRVD UNITS. USE UNITS PER CURRENT 29 CFR
1910.134 & FOLLOW MFR'S INSTRUCTIONS & WARNINGS. IF W/IN OSHA PROT
FACTOR, NIOSH APPRVD A IR PURIFYING OV/FILTER UNITS OK FOR USE.
Ventilation:LOCAL AND MECHANICAL EXHAUST.
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS WITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health
EFTS OF OVEREXP: TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND BIRTH
DEFECTS OR OTHER REPRODUCTIVE HARM.

Boiling Pt:B.P. Text:>280F,>138C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.1 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:VISCOUS LIQUID WITH TYPICAL PAINT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING AND HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.

Waste Disposal Methods:USE INERT ABSORBENT MATERIALS ON SPILLS. DISPOSE
OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.